2 Ton Industrial Gas Fired Steam Boiler With corrugated furnace

Energy-saving boiler which brand is good, this is the majority of customers are more and more concerned about the problem. With the domestic attention to air pollution control, the surrounding areas of Beijing, Tianjin and Hebei in China have issued control measures according to the actual situation, among which the elimination of small coal-fired boilers is one of the important measures. Gas-fired boilers, oil-fired boilers and electric heating boilers all belong to energy-saving boilers, but compared with coal-fired boilers with serious pollution, the fuel cost is still higher, which increases the use costs of customers. Customers are also more concerned about the energy-saving effect of boilers, as far as possible to reduce costs. So which brand of energy-saving boiler is good? Now push for you. Recommend national A class boiler high-tech enterprise-Fangkuai boiler. Energy-saving boiler is a series of products that we focus on research and development of Fangkuai boilers. The thermal efficiency of natural gas boiler is very high, our Fangkuai can reach 95% or more, the emission of gas is very friendly to the environment, the nitrogen oxide is less than 30mg, which meets the relevant rules and regulations in our country. In some of the more remote areas, some countries have limited power to factories. At this time, the oil-fired boiler is a good place, with the domestic improvement of fuel quality, Fangkuai The continuous development of new technology has greatly improved the energy-saving effect of the boiler. Electric boilers can be said to be a leader in environmental protection boilers, but electricity is a valuable secondary energy source, and most of them are converted from coal-fired thermal power generation. Some areas are still short of electricity supply, and there is also a power limit every summer peak. Therefore, it is not the domestic promotion of energy-saving boilers. Another reason is that it costs about twice as much as a gas-fired boiler. Again, we strongly recommend a new type of energy-saving boiler-tubular boiler, which has a combustion efficiency of up to 96% and is very friendly to the environment, that is to say, the special performance of 3-minute steam output is available as soon as it is opened. Can save you a lot of fuel. Some customers may think that compared with traditional boilers, the price is a little more expensive, but what we have to say is that we have reasons for expensive, high-tech applications have greatly improved thermal efficiency, saved a lot of fuel, from the long-term investment use, The price-to-performance ratio is super high. Through the above understanding of energy-saving boilers, I believe you have a certain understanding of our Fangkuai boiler brand, want to have a more in-depth understanding, please call our hotline, more sincerely invite you to visit the plant, study.

In recent years, Ningbo municipal government attaches great importance to environmental protection, air pollution prevention and control work to strengthen the organization and leadership, the establishment of a multi-sectoral collaboration to air quality at the core of the atmospheric environment management systems. And introduced a new quality of atmospheric environment deadline for compliance plan, as follows.

Strict implementation of total coal consumption control, to further optimize energy consumption structure, strive to 2020, coal consumption accounts for the proportion of primary energy consumption control in about 40% of coal consumption is not higher than 2011 levels, and completely cut coal province issued the task .

Strengthen management work focused on coal-fired projects, continue to promote the elimination of the transformation of small coal-fired boilers. 2019, phasing out 10 steam tons / hour of coal-fired boilers and, in 2020, the county level and above urban area basically eliminated tea furnace, operating a stove, grain storage and drying equipment, coal-fired facilities; basically eliminated the city's 10 -35 steam t / h coal-fired boiler; 35 t steam / hour and more polluting fuels and ultra-low emissions energy boilers complete transformation.

Strengthening coal quality control, within the city limits the use of ash> 16%, sulfur> 1% low-quality coal, fuel encourage high value, low sulfur, low ash blending works. 2019, the establishment of the city's coal regular testing, sampling tests system. In 2020, the city's clean coal utilization rate of 90%.

Increase natural gas use, and actively promote major infrastructure construction official website of natural gas, LNG receiving station and other utilization of natural gas, natural gas Daly improve utilization levels.

Enhance the energy efficiency of industrial enterprises. Actively promote advanced energy conservation projects integrated coal demonstration projects, large-scale generating units coal consumption reached the advanced level of the same type of unit.

Development of central heating, central heating project to optimize the layout, promote industrial parks focused on central heating. Focus on industry gathering area, industrial park development of cogeneration, and encourage qualified development of thermoelectric cooling area for the triple. Further improve the matching of heating pipe network, construction of efficient, fast heat pipe network. 300,000 kilowatts and above cogeneration power plant 15 kilometers behind the small coal-fired boilers and coal-fired thermoelectric heating within a radius of all closed down integration.

Successful ignition of fuel 2 ton industrial fired steam boiler with corrugated furnace can not run, because of those common oil gas powered steam boiler applications, all of you should ignite the fuel steam boiler in the application process, no way ignition is also the most common problems. Fuel steam boiler in the application process, most likely resulting in no way ignition, resulting in fuel steam boiler can not run normally, small series to introduce you to a steam boiler does not ignite the fuel to run those common reason. Fuel steam boiler can not run common ignition of those reasons: First, the ignition problems: pulse ignition and control systems such as the one of which has caused the problem, the fuel steam boiler can not start. Second, the battery thing: to be very important to see if the battery is a battery in the end is not too aging. The charge is not standard, the same can not let steam boiler fuel ignition. Third, the water pressure thing: at the inlet steam boiler fuel filters block the formation of water can not flow normally through the clean up clean ok. Fourth, the pulse valve problems: If the boiler ignited fuel vapors to ignite division saw sound, no pulse valve "despair" squeak, probably for the pulse valve is damaged or degraded, pulse valve degeneration, will not manipulate, the beginning of the ignition operation when closing a flow will hit a fire, but the fire immediately and confinement; pulse valve before confirm whether there is a problem to confirm whether normal ignition actuating member, if the fault can not pull the valve actuating pulse. V. ignite feelings needles or needle thing: fuel steam boiler ignited hand shift. You can change or correct the ignition pin arrangement; if feelings of degradation promise things, as long as the feeling wiped clean arranged on it. Six, usually no way to exhaust smoke tube. Smoke tube steam boiler with a fuel block, clean breathing tube blockers smoke tube is too long, the configuration is not correct. Referring may be configured to inform two coaxial cigarette heater tube. VII vapor setter joint problems: fuel steam boilers, water vapor degradation intimal flap valve or joint damage, not the weak control push button switch; weak bad control switch button.

The inlet speed of gas-fired hot-water boiler before start-up should not be too fast, usually no less than 4 hours in winter, and 2-3 hours in other seasons, especially in the initial stage of water intake. The inlet temperature of a gas-fired hot water boiler is generally 50 °C, so the difference between the feed water temperature and the steam wall temperature in the drum is less than 40 °C. For gas-fired hot water boiler, the inlet water temperature can be equal to that of steam drum wall without complete cooling, otherwise the inlet water speed should be slowed down. When feed water enters the drum, it always first touches the lower part of the drum. If the difference between the feed water temperature and the drum wall temperature is too Large, the inlet speed is fast, and the upper and lower walls of the drum, the inner and outer walls will have a large expansion. Bad, on the drum caused a lot of additional stress, resulting in drum deformation, serious cracking. Due to the thickness and slow expansion of the drum wall, the tube wall connected to the drum wall is thinner and expands faster. If the inlet temperature of the gas-fired hot water boiler is too high or the inlet speed is too fast, the expansion will be uneven, the welded joint will appear cracks and the gas-fired hot water boiler will be damaged. The inner diameter of the decompression tube is usually φ 7~13mm (water and steam), and its length should not be too long (< 60m). Straightness of pressure pipe If the diameter is too small and the length is too long, it will affect the dynamic transmission of pressure measurement and increase the dynamic error. The inner diameter is too large to be easily maintained and installed. Pressure pipes should not be placed in the horizontal part to prevent the accumulation of bubbles (when measuring liquids) and water columns (when measuring gases). The pressure tap shall be perpendicular to the flow of the medium. Pressure faucet must not have chamfer, flange and burr. When measuring the hydraulic pressure of an electrically heated 2 ton industrial fired steam boiler with corrugated furnace, the pressure outlet should be removed from the lower part of the pipe to prevent the gas in the liquid from entering the pressure guide pipe; When measuring the gas pressure, remove the pressure splice from the upper part of the pipe to prevent dust and dust in the gas The droplets enter the ignition line. The installation site of the electric heating steam boiler pressure gauge (pressure transmitter) should meet the environmental conditions (temperature, humidity, vibration, etc.) used by the instrument, and should be easy to observe, repair and ensure safety. Insulation should be laid on pressure pipes in high temperature media to avoid burning during flushing. Pressure lines are equipped with needle valves (for cutting off pressure in the event of pressure line failures during operation), auxiliary needle valves (for use with instruments, stopping, replacement), condensing coils and elbows (isolation elastic elements from high-temperature media), Easy to install sealing gaskets) as well as sewage valves and sewers. For special pressure measurements, it's still pressing. Install discharge valve, isolation room and so on in the force pipe.

2 Ton Industrial Gas Fired Steam Boiler With corrugated furnace Related Information

Gas Water Tube Steam Industrial Boiler -

2 Ton Oil And Gas Fired Steam Boiler Once Through . Automatic gas fired high efficiency once-through LSS Type boiler is a new type of high-tech energy saving product. It can produce steam in cold water condition within 3-5 minutes.While the traditional oil/gas fired boiler generate steam will take 30-40 minutes. Free Chat

Get a Quote

Boiler & Furnace - China Boiler, Steam Boiler

China Factory 0.5 Ton to 20 Ton Gas Diesel Waste Oil Fired Industrial Steam Boiler Price Yuanda WNS series oil/gas fired boiler adopts horizontal three-pass wet-back Henan Yuanda Boiler Corporation Ltd.

Get a Quote

2 ton,steam boiler

2020-3-14 · The 2 ton coal fired steam boiler sea freight is need one 40 fram and one 40 container . the boiler size :5900*2600*3252mm the boiler weight :25ton DZL series single drum type chain-grate boiler, using water and fire tube structure, high temperature flue gas inside the drum three return, threaded pipe, and other advanced technology.

Get a Quote

Remarkable Industrial Gas Fired Steam Boilers Energy

Quality Gas Fired Steam Boiler manufacturers & exporter - buy Remarkable Industrial Gas Fired Steam Boilers Energy Saving Effect With Fast Installation from China manufacturer.

Get a Quote

3 Ton Industrial Gas Fired Boiler / Horizontal Three

3 ton industrial gas fired boilers Yongxing WNS3-1.25-YQ horizontal three return gas steam boiler wholesale . industrial gas fired boilers General Introduction. The company's WNS series horizontal internal combustion boiler is a shell-type three-return wet back fuel (gas) boiler. 1. The boiler operation is fully automated. 2.

Get a Quote

2 ton oil gas fired boiler parameter and feature, oil

2019-11-28 · The WNS series boiler is horizontal three-pass fire tube gas oil boiler. It is mainly composed by boiler shell, furnace, combustion chamber, flue gas pipes, etc. This paper will give some main technical parameters of 2 ton oil gas fired steam boiler. 2 ton oil gas fired boiler parameter. Boiler model: WNS2-1.25-Y(Q) Rated steam capacity: 2t/h

Get a Quote

Propane Fired 200 bhp 3 ton Steam Boiler

Fire tube Propane Fired 200 bhp 3 ton steam boiler. Capacity:3 ton steam boiler,200 bhp boiler. Fuel:diesel,heavy oil,propane gas,lpg,natural gas. 1.Fire tube 3 pass oil gas steam boiler. 2.Combustion chamber with large volume; 3.Spirally corrugated tube, strengthening heat transfer and eliminating welding stress; 4..PLC Intelligent Control

Get a Quote

Gas Fired Boiler - Gas Fired Steam Boiler Gas Fired

WNS series gas fired boiler includes gas fired hot water boiler and gas steam boiler for industrial steam generation and supply.Our gas fired boiler is designed and engineered with the three-pass full wet back structure, adopting large furnace and thick smoke pipe to increase the heat absorption of the furnace and effectively save energy and reduce consumption.

Get a Quote

Compact WNS 3 Ton Fuel Gas Steam Boiler, Fire Tube

The corrugated furnace increases the heat transfer area, increases the rigidity of the furnace, and satisfies the free expansion of the furnace after being heated. (6)The wet back structure avoids the direct flushing of the high temperature flue gas to the rear smoke box, which improves the reliability of the boiler

Get a Quote

2 ton gas steam boiler, 2 ton gas steam boiler

Alibaba.com offers 2,922 2 ton gas steam boiler products. About 98% of these are Boilers. A wide variety of 2 ton gas steam boiler options are available to you, such as usage, type, and output.

Get a Quote

Energy Saving Chain Grate Industrial Steam Boiler

Energy Saving Chain Grate Industrial Steam Boiler ISO9001 Certification . Yuanda Boiler series---WNS, DZL, SZL . WNS horizontal fire tube gas oil fired steam/hot water boiler . WNS series gas/oil fired steam boiler is horizontal three pass fire tube wet back full automatic steam boiler.

Get a Quote

corrugated for boiler, corrugated for boiler Suppliers

Alibaba.com offers 925 corrugated for boiler products. About 11% of these are Boilers, 0% are Boiler Parts. A wide variety of corrugated for boiler options are available to

Get a Quote

Corrugated furnace - yd-boiler.com

2020-5-15 · The central part of a shell boiler is the furnace where the flame burns out by releasing extensive energy. Due to its shape the corrugated furnace is more stable than the plain furnace and thus can withstand the operating parameters of a high-pressure boiler.

Get a Quote

Wns Series Automatic Gas or Oil Fired Steam Boiler -

Nanning, Guangxi, China. Member Since: 2018. Business Type: Trading Company. 86-15093412637. 86-15093412637. 86--15093412637

Get a Quote

Propane Fired 200 bhp 3 ton Steam Boiler

Fire tube Propane Fired 200 bhp 3 ton steam boiler. Capacity:3 ton steam boiler,200 bhp boiler. Fuel:diesel,heavy oil,propane gas,lpg,natural gas. 1.Fire tube 3 pass oil gas steam boiler. 2.Combustion chamber with large volume; 3.Spirally corrugated tube, strengthening heat transfer and eliminating welding stress; 4..PLC Intelligent Control

Get a Quote

Related Information

DO YOU HAVE QUESTIONS? WE ARE HERE TO HELP YOU!