china gas fired steam boiler manufacturer

At 10:00 on September 6 and more, Harbin, a business is the purchase of a new boiler equipment installation, commissioning process when staff at a boiler pressure gauge index found that the performance of the boiler abnormal, but not so the commissioning personnel when the next step, a sudden loud noise, boiler explosion, a huge flame and furnace pressure debugging of oil spray everywhere, four commissioning personnel are subject to varying degrees of injuries, was taken to hospital for treatment .

Boiler is an energy conversion device, by entering the fuel to the boiler, chemical energy, power, etc., outputs a constant steam heat, hot water or organic heat carrier, to provide support for the heat industries. Meanwhile, the boiler is also a special equipment has a certain risk, when the boiler installation, commissioning, operation, etc., be sure to boiler operation safety first.

Now, Xiao Bian to operational safety considerations gas boiler summarize, we can refer to.

First, start, boost, steam supply

1, before the start of the preparatory work

Internal and external check: Check boiler, burner, a good state of the accessory device; action safety accessories, each of the valves, such as flexible instruments, the correct position.

Check the line voltage to meet the requirements, a variety of normal switch position, respectively, various auxiliary pump starts operating, the burner fan, oil pump is normal.

Boiler Feed: exhaust valve opening, to ensure the normal water level (just below the water level).

2, start

Firstly purging the furnace, induced draft fan suction time is usually about 10 minutes to ensure that no residual gas in the furnace, passing substitutions, and ignition for combustion air supply.

After firing is completed according to the adjustment amount of load required for combustion, the boiler into normal operation.

During startup, to closely monitor changes in water level, water boiler accident or occurrence textile full of water accidents.

Second, the normal operation

1, the water level

Fuel gas-fired boiler water table should be the red line indicating the high, medium and low water level, the operation shall not exceed the maximum safe level or below the minimum safe level.

Rinse water table at least once per shift, when there is suspicion of running water, rinse should always check.

2, steam pressure

Red lines indicate the working pressure gauge should have, so sensitive and reliable, the trap should be flushed at least once a week.

3, safety valve

Safety valve should seal intact, no leakage; once a week manually (or automatically) emission test, and begin start pressure, opening pressure, reseating pressure and test time, participants, etc credited maintenance log book u, for future reference .

4, sewage

Proceed as boiler water quality requirements of water quality testing personnel under the guidance of class 1 or 2 times sewage, sewage incident not too long, generally no more than 10 minutes.

Sewage should (preferably when shutdown), should be closely monitored sewage water level changes, and pay attention to safety at the time of low load, low pressure, high water level.

Many boilers when sharing a sewage mains, while sewage is prohibited.

Third, shutdown

1, the normal shutdown

After normal boiler shutdown should generally be reduced boiler load operation, press the boiler shutdown procedure. Actuated pump water to high water level, pressure steam boiler to be dropped after 0.3MPa flushing water table and sewerage operations, and finally close the raft, cut off the power supply control cabinet, wipe equipment, clean up the environment and health, For water, the water temperature should be below after 70 ℃, before proceeding.

2, emergency shutdown

When the boiler operation in the following situations should immediately shutdown:

Furnace water level drops below the minimum water level gauge visible edges.

Increasing water supply and other measures, but digital still continue to fall.

Boiler water level exceeds the highest visible water table level (full of water), the water still can not see the water level.

All water supply system water pump failure or malfunction, not water to the boiler.

Water gauge or safety valve all the failures.

Endanger the boiler element is damaged and the safety of operating personnel.

Combustion equipment damage, or furnace wall collapse and other red-hot boiler structure is a serious threat to the safe operation of the boiler.

Other anomalies endanger the safe operation of the boiler.

3, maintenance

Before maintenance work should be well prepared, as before entering the drum interior work, must be of sufficient strength to connect all of the metal blocking plate spaced reliable steam, water, sewage and other operation of the boiler pipes, and the drum manholes and hand holes (boiler shell) is opened, so that air convection period.

After the completion of preparations to repair. Should ensure that the quarterly frequency of boiler maintenance and repair of the year.

Advances in technology to the boiler industry into new and innovative ideas, now the boiler manufacturers boiler are easy targets toward the operation forward, but in the use of the boiler, improper operation or other quality problems still exist, these failures will It is causing the direct cause of the explosion boilers. Therefore, when using the boiler must be in strict accordance with safety practices boiler, security incidents strangled in the cradle.

How to choose the heat exchanger is a china fired steam boiler manufacturer Shandong? To steam boiler insulation damaged condition for viewing prior to use, view of the burner, to see whether the normal operation, but also to see to make sure the valve open position is correct, to view the attachment security equipment, instrumentation equipment and devices automatic control equipment must meet the requirements. Point blast furnace steam boiler admit items are: open oil circulation pump before and after the valve, the valve open oil heating process, mediation high tank level in a reasonable position, admitted that the gas pressure before the gas burner must be burned in power scale, power supply normal.

About the advantages of gas-steam oven gas is mainly reflected in what way in recent years, with the continuous development of the boiler industry, a variety of devices including gas, including gas-steam oven has been further developed and applied. We know that the production of each device can be widely used. It has its own advantages, the main advantage of what gas furnace gas and steam are we talking about today? According to reports, the gas can understand that gas-steam oven does not require the accumulation of ash, thus eliminating area. When the gas for a fuel delivery gas steam oven, other auxiliary machines less, low-power, continuous operation time is short, and therefore at a high level, saving electricity. Production of heat transfer oil boiler. Others because the gas furnace gas and steam will now run out of dust and pollution, natural gas is used as a clean energy source. In the Gas Gas steam oven operation, no pollution, and it is easy to achieve. Nightly environmental needs. Daily use of gas gas steam oven needs maintenance. When not in use the boiler, should carry out maintenance and maintenance. This will not only extend life, but also can reduce the use of various problems arising in the process. First of all, when not in use boiler, heat transfer oil to be discharged of all internal, because if there is oil, the quality will change. If a leak occurs, it will affect the surrounding environment, and needs to be cleaned after release. Clean the inside of the boiler to maintain and keep other impurities. Secondly, regularly check the various components of the gas oil furnace to see if there are loose. After maintenance, the boiler can be stored, can be used directly in the next use, not other problems. Xiao Bian remind you, after using a gas furnace gas and steam for some time, the loss will occur. If the loss is too large, it will affect their use, particularly in certain connections and transmission loss larger. Add lubricant to reduce the loss of these components and more stable performance of the boiler.

In order to ensure boiler safety, to run smoothly, you must ensure that the use of high-quality natural gas. 1, equipped with one gas separator to increase the capacity, it can effectively store oil and water. Secondly, a level gauge designed to directly observe whether there is liquid in the separator. While the design of the automatic drain pressure relief device is installed. A single control pressure of the air is improved dual control, i.e. the pressure regulating valve is mounted on the main line to control the water separator, the pressure to stabilize, improve security purposes. 2, safety monitoring natural gas as a boiler room burning materials, natural gas leak monitoring must be done. The portable display technology poor performance, poor sensitivity. Host combustible gas alarm system with digital control scaling circuit having an alarm function and a secondary alarm, ensure the safe operation of the boiler. 3, check before firing the safe operation of: (1) whether the boiler inspection gates normally open or closed, check the gas pressure is normal, not too high or too low, open the supply valve leading to the boiler. (2) in the flue baffle must be fully open, otherwise it will affect the purge, causing accidents. Each knob and keep control cabinet to check the normal position. If the stove has a residue should be cleaned. (5) Check the boiler ignition and fire protection program control means should be flexible and reliable. Blast doors should be flexible and rigorous on the boiler. Before the completion of ignition, the ignition is not possible to start the ignition operation: After successful ignition, the load can be adjusted in the normal operation of the boiler when the combustion gas boiler adjusted. We should always observe the combustion furnace, and adjust the amount of steam, wind and steam pressure to ensure the safe operation of the boiler. Note: Program: first five minutes were furnace cleaning, automatic ignition after 5 minutes, observe the ignition is successful, the success of one minute after a small fire can be operated automatically converted to fire properly. For the boiler load and the air pressure adjusted by adjusting the pressure regulator to achieve. When adjusting the load, adjust the air pressure at the same time, it must be synchronized to adjust the air flow to ensure a reasonable match air volume and air volume, in order to achieve economic operation of the boiler. In normal operation, the amount of gas should not be adjusted or reduced drastically in order to avoid dramatic changes in combustion, the pressure receiving member sudden expansion, shrinkage and damage. When the boiler is running, the pressure gauge must be monitored regularly in order to maintain stable water pressure. BCP pressure changes observed, reflecting the relationship between water temperature and steam consumption. In the boiler operation, when the steam pressure is automatically adjusted, the main purpose of the staff is to monitor automatically adjusts the boiler system is sensitive and timely solutions to problems and ensure the sensitivity and reliability of the automatic control system. 4, first close the main valve shutdown operation, the air supply is stopped, the circulating pump and the water pump is still running, when the boiler water temperature falls below 70, and supplies or stops the circulation pump in operation of the pump after about 4 hours. Note: In addition to the accident and emergency parking stop, parking general approach should not cut off the power. After the shutdown, it is timely for the boiler and ancillary equipment to conduct a comprehensive inspection. If you find a defect in the device, and repair should be recorded at the time of shutdown. Safety Precautions 1. burner startup, if the burner is repeatedly locking and alarm, you should find out the cause of the malfunction, press the reset button after troubleshooting, press the reset button and then continue to boot. Note: Press the Reset button for less than 10 seconds. A lower burner inlet must be clean and clean, and does not allow offal. 2. burner once the ignition is unsuccessful, Boiler Fan should be restarted. Ventilation After 5 minutes, start the second startup burner igniter. three. During normal operation, the thermal device near the burner portion (e.g. flange connections) will be very hot, in order to avoid burns. Do not put flammable materials in the vicinity so as not to cause a fire. 4. The operation of the boiler circulating pump must be closely monitored and the hot water boiler pressure, gas distributor, pipeline valves, pressure gauges, flow meters, water level gauge and the like. 5. When the firefighters open the door or fire door observation, you should wear gloves and a side view. 6. A burner working environment should be kept clean and dry, in particular, a flame detector (i.e. electric eye) should be kept clean, part of the control circuit should humidity and temperature; class should cleaning and maintenance of a combustor. 7. During use, the filter should be cleaned regularly check or replace the filter cartridge in accordance with impurities of the fuel. 8. Check the electrical installations include: wire is damaged, the sheath is damaged, the screw is loose, the contact is good, whether the motor is running abnormal noise. Describes the advantages and disadvantages of natural gas boiler, editor of Sin sets introduced, the use of technology and safety precautions. Industrial boilers to energy efficient, environmentally friendly development direction. Natural gas boiler to meet the needs of these three points. They are the future of the boiler market trend, more and more restricted energy policy, energy saving and environmental protection requirements.

china gas fired steam boiler manufacturer Related Information

China Industrial Oil or Gas Fired Steam Boiler Photos

Steam Boiler, China Steam Boiler, Gas Steam Boiler manufacturer / supplier in China, offering Industrial Oil or Gas Fired Steam Boiler, High Efficiency & Safety Electric Steam Boiler for Steamed Rice, Small Steam Boiler Generating Electricity and so on.

Get a Quote

China Woodworking Machinery Thermal Oil Boiler Hot

Power Boiler, Oil Fired Boiler, Gas Boiler manufacturer / supplier in China, offering Woodworking Machinery Thermal Oil Boiler Hot Steam Boiler with Fixed Chain Grate, Multi-Opening Partcleboard MDF Hot Press with Auto Loader, Small Capacity Automatic Particleboard Machines for Particleboard Production Line and so on.

Get a Quote

China Boiler manufacturer, Steam Boiler, Hot Waer

Boiler, Steam Boiler, Coal Fired Boiler manufacturer / supplier in China, offering Steam Generator for Heat Transfer Oil (pressure vessel), Storage Tank (pressure

Get a Quote

China Gas Boiler, Steam Boiler, Coal Boiler Supplier

Wns4-1.25-Yq 4 Ton 13bar Natural Gas LPG Diesel Oil Waste Oil Fired Steam Boiler for Garment Factory US $ 5,000-150,000/Piece Video

Get a Quote

Quality Gas Fired Steam Boiler & Oil Fired Steam

Zhangjiagang Wilford Thermal Co.,Ltd. is best Gas Fired Steam Boiler, Oil Fired Steam Boiler and Industrial Electric Steam Boiler supplier, we has good quality products & service from China.

Get a Quote

Zhangjiagang Future Thermal Facility Co.,Ltd - Oil/Gas

Zhangjiagang Future Thermal Facility Co.,Ltd China Manufacturer with main products:Oil/Gas Fired Steam Boiler,Electric Steam Boiler,Electric Steam Generator,Hot Water Boiler,Industrial Boiler

Get a Quote

China Boiler manufacturer, Gasfier, Steam Boiler

Boiler, Steam Boiler, Steam Generator manufacturer / supplier in China, offering Steam Generator Biomass 50kg / H Wood Steam Boiler, Vertical Biomass Boiler/Wood Boiler/Sawdust Boiler Manufacture, 50000kcal Wood Pellet Hot Water Boiler for Hotel and so on.

Get a Quote

China Boiler manufacturer, Steam Boiler, Gas Boiler

Boiler, Steam Boiler, Gas Boiler manufacturer / supplier in China, offering 6t Compact Packaged Chain Grate Coal Steam Boiler, Industrial Automatic Feeding Bio Mass Boiler, Bio Mass Type High Efficiency Wood Burning Boiler and so on.

Get a Quote

China Gas Boiler manufacturer, Steam Boiler, Hot

YinYu boiler manufacturing Co., Ltd. is a national fixed-point B boiler pressure vessel manufacturer, our main products are: Vertical coal, gas, fuel steam (hot water) boiler, environmental protection double grate type steam boiler burning, electric heating steam boiler (hot water) boiler, vertical airborne hot, high, medium and low temperature hot blast stove, etc 16 big series, 153 kinds of

Get a Quote

Henan Yuanda Boiler Co.,ltd - steam boiler,hot water

Quality steam boiler,hot water boiler,coal fired boiler for sale, steam boiler,hot water boiler,coal fired boiler & gas-firedboiler provided by China Suppliers - Henan Yuanda Boiler Co.,ltd.

Get a Quote

China Boiler manufacturer, Steam Boiler, Hot Waer

Boiler, Steam Boiler, Coal Fired Boiler manufacturer / supplier in China, offering Steam Generator for Heat Transfer Oil (pressure vessel), Storage Tank (pressure

Get a Quote

Wilford - Boiler & Steam Boiler from China Suppliers

Zhangjiagang Wilford Thermal Technology Co.,LTD China Manufacturer with main products:Boiler,Steam Boiler,Oil Fired Steam Boiler,Gas Fired Steam Boiler,Electric Steam Boiler,Hot-water Boiler

Get a Quote

China Boilers manufacturer, Steam Boilers, Industrial

Qingdao Global Industry Co., Ltd a professional Engineering manufacturing co, We design and supply energy power equipment and ASME certificate professional water tube boilers, fire tube boiler, solid fuel boilers and fluid fuel boilers; Steam tubine, And hot water absorption chiller, steam absorption chiller and direct fired chillers.

Get a Quote

China Boiler manufacturer, Gasfier, Steam Boiler

Boiler, Steam Boiler, Steam Generator manufacturer / supplier in China, offering Steam Generator Biomass 50kg / H Wood Steam Boiler, Vertical Biomass Boiler/Wood Boiler/Sawdust Boiler Manufacture, 50000kcal Wood Pellet Hot Water Boiler for Hotel and so on.

Get a Quote

Biomass Boiler, Electric Heating Boiler from China

Boiler, Steam Boiler, Coal Fired Boiler manufacturer / supplier in China, offering Electric Hot Water Heating Steam Boiler, Thermal Oil Fired Vertical Boiler, Vertical Heat Conduction Oil Boiler and so on.

Get a Quote

Related Information

DO YOU HAVE QUESTIONS? WE ARE HERE TO HELP YOU!